BPGDN - CARBON DIOXIDE
- MSDS: BPGDN
- Manufacturer: ANSUL FIRE PROTECTION WORMALD U S INC
- Product Name: CARBON DIOXIDE
- National Stock Number: 4210-01-042-3400
Product Identification
Product ID:CARBON DIOXIDE
MSDS Date:05/15/1991
FSC:4210
NIIN:01-042-3400
MSDS Number: BPGDN
Responsible Party
MARINETTE, WI 54143-2542
US
Emergency Phone: 715-735-7411/800-424-9300(CHEMTREC)
Info Phone: 715-735-7411
Preparer: DOD-HMIS (DGSC-SSH)
Cage: 03670
Contractor
Telephone: 715-735-7411
Cage: 03670
Ingredients
CARBON DIOXIDE
CAS: 124-38-9
RTECS: FF6400000
Fraction By Weight: 100%
OSHA PEL 5000 PPM
ACGIH TLV: 5000PPM/30000STEL;93
Hazards
LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:PHYSICAL CONTACT WITH
LIQUEFIED/SOLID CARBON DIOXIDE CAN CAUSE FROSTBITE OR FREEZE
BURNS.INHALATION OF VAPOR IN CONCENTRATION OF 3-5% BY VOLUME IN AIR
CAUSES INCREASED RESPIRATION & HEADACHE;8-1 5% CAUSES
HEADACHE,NAUSEA,VOMITING & UNCONSCIOUSNESS.HIGHER CONCENTRATION MAY
LEAD TO COMA & DEATH.CHRONIC:UNKNOWN.
Effects of Overexposure:VAPOR IS HEAVIER THAN AIR AND CAN CAUSE
SUFFOCATION BY REDUCING AVAILABLE OXYGEN FOR BREATHING. MAY CAUSE
DIZZINESS, IMPAIRED COORDINATION, REDUCED MENTAL ACUITY, HEADACHE,
DIFFICULTY BREATHING, DROWS INESS, DEPENDING ON LENGTH OF EXPOSURE
AND CONCENTRATIONS.
Medical Cond Aggravated by Exposure:RESPIRATORY PROBLEMS
First Aid
First Aid:GET MEDICAL ATTENTION.INHALATION:REMOVE TO FRESH AIR.PROVIDE
CPR/OXYGEN IF NEEDED.EYES:IMMEDIATELY FLUSH WITH PLENTY OF TEPID
WATER/STERILE SALINE.SKIN:FLUSH WITH LUKEWARM WATER.DO NOT USE HOT
WATER.P ROMPT MEDICAL ATTENTION IS MANDATORY INALL CASES OF
OVEREXPOSURE TO CO2.RESCUE PERSONNEL SHOULD BE EQUIPPED WITH SELF
CONTAINED BREATHING APPARATUS.
Fire Fighting
Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL FOR SURROUNDING FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:THOUGH GAS CYLINDERS ARE EQUIPPED WITH
PRESSURE AND TEMPERATURE RELIEF DEVICES, THEY SHOULD BE REMOVED
FROM HIGH TEMPERATURES OR FIRE TO AVOID RISK OR RUPTURE.
Accidental Release
Spill Release Procedures:EVACUATE ALL PERSONNEL FROM AREA. USE
APPROPRIATE PROTECTIVE EQUIPMENT. PROVIDE VENTILATION TO AREA AND
AVOID CONTACT WITH SOLID OR LIQUID AND EXCESSIVE INHALATION OF
VAPOR. VALVE OFF CARBON DIOXIDE S UPPLY FROM LEAKING OR BROKEN
COMPONENTS.
Neutralizing Agent:NOT APPLICABLE.
Handling
Handling and Storage Precautions:STORE IN A COOL,DRY,VENTILATED
PLACE.DO NOT INSTALL STORAGE VESSELS IN SUB SURFACE,CLOSED AREA OR
NEAR HEAT/FLAME.
Other Precautions:AVOID PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID
CONTACT WITH EYES OR SKIN. USE WITH ADEQUATE VENTILATION. WASH
THOROUGHLY AFTER HANDLING.
Exposure Controls
Respiratory Protection:POSITIVE PRESSURE AIR LINE WITH FULL FACE PIECE
AND ESCAPE AIR SUPPLY OR SELF CONTAINED BREATHING APPARATUS SHOULD
BE AVAILABLE FOR EMERGENCY USE.
Ventilation:SUFFICIENT TO PREVENT ACCUMULATION ABOVE TLV. LOCAL EXHAUST
SHOULD BE LOCATED NEAR THE FLOOR.
Protective Gloves:INSULATED AND COLD RESISTANT
Eye Protection:SAFETY GOGGLES WITH OPTIONAL FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
THIS RECORD CREATED BY HMIS IN RESPONSE TO A NEED & REQUEST FROM DDOU.
MSDS COPIED FROM ANOTHER ANSUL CO*2 MSDS FOR A SIMILAR PRODUCT.
Chemical Properties
HCC:G3
Boiling Pt:B.P. Text:SUBLIMES
Decomp Temp:Decomp Text:SUBLIMES
Vapor Pres:42928 @20C
Vapor Density:1.5
Spec Gravity:1.98
Evaporation Rate & Reference:GAS AT ROOM TEMPERATURE
Solubility in Water:88% @ 20C
Appearance and Odor:COLORLESS GAS - NO ODOR
Percent Volatiles by Volume:100
Stability
Stability Indicator/Materials to Avoid:YES
STRONG BASES, ALKALI METALS
Stability Condition to Avoid:FLAMES
Hazardous Decomposition Products:NONE
Disposal
Waste Disposal Methods:CONTAMINATED AREA SHOULD BE VENTILATED
THOROUGHLY. SOLID CARBON DIOXIDE SHOULD BE REMOVED OUT OF DOORS AND
ALLOWED TO SUBLIMATE. DISPOSAL SHOULD BE IN COMPLIANCE WITH ALL
LOCAL, STATE AND FEDERAL REGU LATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.